Abmessungen on demand.
POSITIVE PRESSURE DRY SHOT CABINET WITH PAPER FILTER 44
- cabin height 3 m
- heating system hot water serpentine heated
- positive pressure 4,5 KW motor 18.000 m3 Taking filtered fresh
air
from outside and providing flow inside the cabin
- With the cellular fan, it allows harmful gases formed in the cabin
to escape
- exhaust fan 15000 m3 It throws out the paint particles passing
through the filter
- dust filter system All input and output are filtered.
- lighting – watertight lamps 4 Pieces, no arc can be made
without
stratel
- ventilation grilles guidance can be made
- gas intake vents adjustable in 2 directions
- 4 cm insulated polyurethane facade panel
- Automatic sliding door 1 pce width 2 mt and height 2.70 mt
- Side suction filtered grilles
- Suction system paper filter 33
- Electrical distribution panel 1 pce
-
DRY DISCHARGE ROOM WORKING PRINCIPLE
Air taken from the external environment with the Positive Pressure
Fan; In cold
weather, it is heated in the air preparation unit.
Then, the air at optimum temperature is separated from dust and pollen
in EU 4
ceiling filters and released into the indoor environment.
Paint particles move towards the suction direction with the air. Air
is thrown out
with exhaust fans. Thus, it ensures that solvent gas, which is harmful
to health, is
discharged outside the paint booth.
With the flow rate difference between the Positive Pressure Fan and
Exhaust Fans,
positive pressure is created in the cabin and the filtered air is kept
inside.
Therefore, dust etc. can come in from the outside environment (doors).
substances
are prevented from entering.
The air flow in the empty room will be 12m/sec.
POSITIVE PRESSURE DRY DISCHARGE CABINET WITH PAPER FILTER 84
- cabin interior height 3m
- heating system with hot water heating option
- positive pressure with clean air channels filtered from outside
- Cellular fan provides warm air blowing and dirty air removal
- exhaust fan ensures that harmful gases accumulated in the cabin
escape to the
outside
- dust filter system easy to change filter system cost is cheap
- lighting – watertight lamps, non-arcing fixtures without
starters
- ventilation grilles can be adjusted in all directions
- gas suction vents allow the gases accumulated in the corners to be
removed
- 4 cm insulated polyurethane facade panel with special snap
locking
- Automatic sliding doors, double-winged, dust-free, 2 pieces
- - All navigable machines above the cabin are mounted here.
- - Energy cost of the cabin is 8.5KW
DRY DISCHARGE ROOM WORKING PRINCIPLE
The flash off phase is the time period during which the solvent
evaporates
between two dyeings or between the last application and the oven
circuit. This
time is absolutely necessary to ensure that the evaporated solvent
gases on the
painted surface are expelled. Following the hashing phase, drying and
resting in
the same cabin is carried out. In this phase, the drying time is a
highly variable
phase S5348684 that may or may not be necessary depending on the type
of paint and the
application method used. In both cases, the time setting is determined
by the
painter or paint supplier. When the doors are closed and the START
button is
pressed, the aspiration system circulation pressure fans operate. The
circulation
fan heats the air it absorbs from the drying cabin and pushes it back
in through
the ceiling filters, creating the air flow inside the cabin and
providing the most
ideal wood-based paint drying. Solvent vapor accumulation inside the
cabin,
which can reach flammability and explosion levels, is prevented. To
eliminate
the possibility, gas vapor is thrown out of the factory for the second
time with
the waste gas fan.
• Ceiling – Wall Material (Insulation): Sandwich panel (40 mm)
• Heating system: Hot water coil
• Ventilation unit: Cell fan with 6-point vent
• Air handling unit fan section
• Fan type: 12 x 12
• Air flow rate: 8000 m³/h (manufacturing option depending on the
m3 of the cabin)
• Total pressure: 58 mm/sec
• Electric motor: 3hp 1450 rpm
• Sliding automatic controlled doors (double wings)
• Length: 225 cm Width: 200 cm
• ● Harmful gas removal unit is available
Price from 22.000 EUR depending on the dimmensions of the cabin
Romania
60731 Bacau 
